#MY HEATING WATER BOILER AQUATERM HOW TO#

If the door gasket is more than 2-3 years old, replace the door seal gasket. Poor outdoor boiler door seal rope / Fan SealĪgain, an unlimited supply of air to the firebox is bad - it will lead to uncontrolled burning of wood fuel in the firebox that will damage the firebox steel.

Reset the high limit switch by pressing the red button until it clicks and the fan and light have power. If this happens while the fire is burning hot, then without the pump circulating water, the water temp in the outdoor wood stove will rise and likely trip the high limit switch. Turn off breaker for 3 min, turn back on. For replacement of high limit switch CLICK HERE.Ĭan cause the boiler pump to stop running. Click HERE for more info on High Limit Switches. Or it may last 12+ trips.Īlways have a spare on hand. A very high temp situation may kill the switch in one trip. This depends upon how hot and how many times the furnace has high temps. Also, High Limit Switches have only a limited number of trips in their lifespan. Must wait until the water temp drops below approx. For replacement pump special, call (231) 861-8200 or check available circulating pumps here.

#MY HEATING WATER BOILER AQUATERM HOW TO#

See the article on how to diagnose pump failure by clicking on this link HERE.

Remove the silver button on the face of the pump while it is in operation to verify the impeller shaft is spinning. The door should only be open for brief moments to add wood fuel to the firebox and remove ash. Please never leave the furnace firebox door open for extended periods of time.

Water temp is over 190, in some cases over 210.Īn unlimited supply of air to the firebox is bad - it will lead to uncontrolled burning of wood fuel in the firebox that will damage the firebox steel.

We recommend that you evaluate the possible causes (listed below) and the corresponding solutions (also listed below) so that you can take the necessary steps to PROTECT your outdoor boiler from permanent damage. If your outdoor wood boiler has overheated, you may have a problem that will permanently damage your boiler. Has Your Outdoor Wood Boiler Overheated? How To Avoid Permanent Damage?

My heating water boiler aquaterm